General Motors recalls 1.4M older cars to fix oil leaks that can cause engine fires

DETROIT – For the third time in seven years, General Motors is recalling cars that can leak oil and catch fire, in some instances damaging garages and homes.

The recall, which covers 1.4 million vehicles, including 125,783 in Canada, dating to the 1997 model year.

It is needed because repairs from the first two recalls didn’t work. More than 1,300 cars caught fire after they were fixed by dealers, the company said.

In the previous recalls, in 2008 and 2009, GM told owners to park the cars outside until repairs can be made since most of the fires happened shortly after drivers turned off the engines. A spokesman was checking to see if the same recommendation applies this time.

In addition, GM will notify owners of 500,000 more cars that were not repaired in the previous recalls, spokesman Alan Adler said.

The latest recall, mainly in North America, includes: the 1997-2004 Pontiac Grand Prix and Buick Regal; the 2000-2004 Chevrolet Impala; the 1998 and 1999 Chevrolet Lumina and Oldsmobile Intrigue; and the 1998-2004 Chevrolet Monte Carlo. All have 3.8-litre V6 engines.

Over time, a valve cover gasket can degrade, allowing oil to seep out. Under hard braking, oil drops can fall onto the exhaust manifold and catch fire. Flames can spread to a plastic spark plug wire channel and the rest of the engine.

GM says it has reports of 19 minor injuries in fires caused by the cars. In 2008, a GM spokeswoman said the cars were responsible for 267 fires, including at least 17 that burned structures.

The problem first surfaced in 2007, when 21 consumer complaints about engine fires in some of the cars prompted the National Highway Traffic Safety Administration to investigate. That probe found three injuries. Most of the blazes happened five to 15 minutes after the engines were turned off, according to agency documents.

The investigation led to the recall in March 2008 of more than 200,000 U.S. cars with supercharged engines. A year later GM recalled almost 1.5 million more cars that weren’t supercharged. Dealers replaced the spark plug wire channels but documents filed with the government don’t mention any repair of the oil leaks.

GM is finalizing a fix in the most recent recall. The company will use state registration databases in an effort to track down the owners and notify them by mail, he said.

The 1,300 fires were discovered when GM began investigating whether to recall some 2004 models that weren’t part of the earlier recalls, Adler said. He said he didn’t know why the recall wasn’t done sooner given the large number of fires.

Company investigators ultimately found 1,345 fires in previously recalled cars and decided “that the recall would be to come up with a better fix for the vehicles that were out there,” Adler said.

The recall is so large that it could have an impact on GM’s fourth-quarter earnings, although Adler said that hasn’t been determined.

“Since we have not decided on the remedy, we do not know whether the cost will result in a material charge to earnings,” he said.